Description: Welcome toLarry's Small Engines. THIS IS BOTH THE 610901 AND 610909 TECUMSEH 20 AMP FLYWHEEL THAT WAS FOUND ON THE HH120, OH120, OH140, HH140, HH150, HH160, OH160 AND OH180TECUMSEH CAST IRON ENGINES.THE DIFERENCE BETWEEN THE 610909 AND THE 610901 IS THAT TECUMSEH STARTED OUT WITH A EARLIER STRAIGHT TOOTH RING GEAR AND THEN LATER MADE A CUTAWAY TOTHE TEETH ON THEM SO IT WOULD HELP THE STARTER MOTORS BENDIX GEAR TO SLIDE IN AND OUT OF THE FLYWHEEL TEETH A LITTLE EASIER.THIS FLYWHEEL HAS NO MISSING COOLING FINS, NO MISSING STARTER GEAR TEETH, ALL SIX THREADED HOLES WERE CLEANED OUT WITH A TAP FOR THE AIR INLET SCREEN AND PTO DRIVE SHAFT THAT WERE USED ON LATER BOLENS MODELS. ALL 6 MAGNETS ARE GOOD AN SECURE TO THE FLYWHEEL AND THE TRIGGER PINS ARE RIGHT WHERE THEY NEED TO BE.YOU GET JUST WHAT YOU SEE IN THE 4 PHOTOS.WE IMPLORE YOU TO READ EVERYTHING BELOW BECAUSE IT WILL SAVE YOU HUNDREDS IN LATER COST!!!IT IS NOT A MATTER OF "IF" BUT MORE LIKE A MATTER OF WHEN!!!!!WE ARE THE GO TO PLACE FOR TECUMSEH CAST IRON PARTS AND GREAT NEED TO KNOW INFO!DO NOT JUST INSTALLED ANOTHER FLYWHEEL AND PUT THE COVER BACK ON WITHOUT EVEN CHECKING FOR PROPER CLEARENCE OF THE ENGINES STARTER MOTOR BENDIX GEAR TO FLYWHEEL RING GEAR TEETH! YOUR ENGINES STARTER MOTOR DOES HAVE ENOUGH UP/DOWN AND SIDE TO SIDE PLAY TO ACHIEVE PROPER CLEARENCE.INSTALATION:AFTER YOU HAVE THE FLYWHEEL INSTALLED, UNDO THE COIL WIRE FROM THE SPARK PLUG AND PUT IT ASIDE. NOW FIX YOUR EYES TO WHERE YOU WILL BE ABLE TO SEE WHERE BOTH GEARS WILL COME INTO CONTACT WITH ONE ANOTHER AND THEN REACH OVER AND TURN THE KEY SWITCH TO THE STARTER TAKE OFF POSITION.REPEAT THAT STEP, TWO TO THREE TIMES TO MAKE SURE THERE IS NOT EVEN THE SLIGHTEST STICKING BETWEEN BOTH GEARS. IF YOU DO SEE SOME STICKING, THEN YOU NEED TO LOOSEN ALL THREE STARTER BOLTS, LIFT AND HOLD STRAIGHT UP ON THE STARTER MOTOR EVENLY AND TIGHTEN THE BOLTS BACK DOWN ON THEM.NOW DO ANOTHER TEST.THE STARTER MOTORS BENDIX GEAR SHOULD NOT BE TIGHT AT ALL TO THE FLYWHEEL.THE PROPER INSTALATION WILL KEEP YOUR STARTER MOTOR FROM EVER DAMAGING THE FLYWHEELS RING GEAR TEETH OR CAUSING THE BUSHINGS TO WEAR OUT FASTER IN THE STARTER MOTOR.THAT OEM TECUMSEH STARTER MOTOR IS OVER 150 DOLLARS TO GET NEW!!! STAY THE HELL AWAY FROM THOSE JUNK CHINA STARTER MOTORS THAT HAVE THESHALLOW BRUSHS IN THEM WITH WEAK SPRINGS!!!!CHINAS BENDIX GEARS ARE NOT MADE WITH STRICK TOLERANCES!!!THAT IS BECAUSE CHINA WILL MAKE THOUSANDS OF BENDIX GEARS WITHOUT CHANGING OUT THE BEARINGS IN THE MACHINE (CALLED; INDEXING MACHINE) UNTILL THEY ARETOO SLOPPY! THIS CAUSES THE BENDIX GEAR TO NOT BE MADE RIGHT!!! THIS WILL CAUSE YOUR FLYWHEEL RING GEAR TEETH TO GET CHEWED UP BECAUSE THEBENDIX GEAR IS TEMPERED TO A HIGHER HARDNESS THAN THAT OFTHE TECUMSEH FLYWHEELS RING GEAR TEETH IS. TECUMSEHS FLYWHEEL:THIS FLYWHEEL IS NOW A NLA (NO LONGER AVAILABLE) PART TO GET NEW!!!MESSICKS . COM WAS THE LAST PLACE THAT WE SEEN WHERE YOU COULD STILL GET THIS NEW BUT THAT WAS AROUND 6 YEARS AGO NOW. WE BELIEVE THEY STILL HAVE THE PRICE ON THEIR WEBSITE OF$308.00 DOLLARS PLUS A SHIPPING AND HANDELING CHARGES ALONG WITH A 10 TO 15 DAY WAITING PERIOD.AS A NOW OVER 40 PLUS YEAR TECUMSEH BUSINESS SELLER,WE ARE THE GO TO PLACE FOR PARTS NEW AND GOOD USED ALONG WITH EXCEPTIONAL KNOWLEDGE ON THESE OLD CAST IRON DUKE ENGINES.TAKE A MOMENT TO SEE OUR FEEDBACK ON THEPARTS WE HAVE SOLD FOR THESE ENGINESHERE IS JUST A FRACTION OF THE FEEDBACK THAT WE RECEIVED FROM THOSE WHO HAVE PURCHASED THESE FROM US. Item as described. Seller very helpful with project. A+++++++...................................................................Buyer..debrepair (393)TECUMSEH 610906, 610855 CASE 1816B HH160 BOLENS SEARS MILLER BLUESTAR 2E.............$280.00...(#256168579574)Exactly as described an works flawlessly! These guys know what they are doing!Please use doing business gents!...............................................................................................................Buyer..jteezy3699 (241)59437 FLYWHEEL, 14547 REGULATOR, 59583 Stator Alternator........................................................$268.89....(#266359580869)Yes, looks amazing on outside of product, like it just came off of theoriginal assembly line. Seller does fantastic work would recommend him to other people looking for a carburetor for Tecumseh engines to talk to them first........................................Buyer..nickbur_0 (7)WALBRO CARBURETOR ARGO 6x6 OH140, OH160 Tecumseh MILLER BLUESTAR SEARS 16/6....$280.00..(# 256087927374)The description was perfect and I was able to get the part that I needed to fix my engine....TECUMSEH 20 AMP STATOR COIL ALTERNATOR BOLENS SEARS MILLER WELDER 2E...............................(# 266123766433)Very pleased, item well packaged. It’s working good..................................................................................Buyer.........tbhpvh (31)TECUMSEH 20 AMP STATOR COIL ALTERNATOR BOLENS SEARS MILLER WELDER 2E..............................(# 254863954117)The best seller I have had the pleasure of buying from and the communication was outstanding and very helpful.The items were expertly cleaned and reconditioned. Fit Perfectly and Works Great.An excellent source of parts for the old Tecumseh engines...THANKS AGAIN..................................Buyer..potbellyman1 (640)TECUMSEH STATOR COIL, FLYWHEEL, REGULATOR & WIRING HARNESS.....................................................(#254941286683)Thanks for the fix...my case 1816b uniloader is running..............................................................................Buyer....tecincog (918)TECUMSEH 20 AMP STATOR COIL ALTERNATOR BOLENS SEARS MILLER WELDER 2E................................(#264785482737)Great seller!!!...............................................................................................................................................Buyer..marjorie3271 (138)TECUMSEH 20 AMP STATOR FLYWHEEL OH120 OH140 OH160 OH180 ENGINE MILLER BLUE STAR............(#254764320637)good product great packing thanks jopier.......................................................................................Buyer..jopier_6305 (207)Tecumseh 610761 Alternator Stator Charging 610747 HH100, HH120, OH160, MF 10, 12.....................(#256288641200)OK Product................................................................................................................................................Buyer.3home160bella (302)TECUMSEH 610906, 610855 CASE 1816B HH160 BOLENS SEARS MILLER BLUESTAR 2E...............$280.00..(#256219912799) THE ITEM/ FLYWHEEL WILL BE SAFLY SHIPPED IN A 12 X 12 BOX WITH A COST OF AROUND 23.20 TO ANYWHERE IN THE LOWER 48 STATES. WE HAVE SOLD AND PACKED MANY OF THESE FLYWHEELS FOR SHIPPMENT. NEVER ONCE HAS ANY ARRIVED DAMMAGED! This is labeled as parts because if the buyer changes their mind then the shipping cost to and from will not fall on us.That is just nonsense that any business would pay for anyones own mistake or change of mind.Specially at the cost of what these weigh to ship.IF YOU HAVE ANY QUESTIONS, PLEASE DO NOT HESITATE TO CONTACT US.WE HAVE MANY EXPLOADED DISCS AND MANUALS ON THE TECUMSEH ENGINES. ALL AVAILABLE TO OUR CUSTOMERS WITH GETTING THEIR ENGINES UP AND RUNNING BUT AGAIN, WE CANNOT HELP, IF YOU DO NOT ASK. PLEASE READ THIS.It is very important for us to satisfy.We try to be as accurate as possible in our descriptions. Unless it is brand new, we upload videos of most of our parts. A picture says 1,000 words but, A video will say 1,000 pictures. Only then does one know what They are truly getting for Their money. We do try to do Our very best at striving for all stars.Thank you for taking the time to view/read this listing.We appreciate Your business.Larry's Small Engines/Salvage.
Price: 179.99 USD
Location: Winn, Michigan
End Time: 2024-10-07T21:06:06.000Z
Shipping Cost: N/A USD
Product Images
Item Specifics
All returns accepted: ReturnsNotAccepted
Compatible Brand: Craftsman, Lauson
Power Source: Tecumseh Gas Single Cylinder
Color: DINGY BROWN COLOR
Compatible Model: HH100, HH120, OH120, HH140, OH140, HH150, HH160, OH160, OH180
MPN: TECUMSEH, FLYWHEEL, HH140, OH140, HH160, OH160, OH180, 610901, 910909 20 AMP, TECUMSEH, FLYWHEEL, ALTERNATOR, STATOR, 610902 STATOR, FLYWHEEL, TECUMSEH, ST/12 SEARS, HH120 ENGINE, TECUMSEH 610901 FLYWHEEL, MILLER, BLUESTAR, 2E WELDER, FLYWHEEL, MILLER, ROUGHNECK, 2E FLYWHEEL, CASE 1816 FLYWHEEL, TECUMSEH, CASE 1816B D 66423 FLYWHEEL, TECUMSEH
Material: Iron, Cast Iron
Brand: Tecumseh
Type: Engine
Horsepower: 12, 14, 15, 16, 18
Number in Pack: 1
Voltage: Magneto
Model: SEARS ST/16 BOLENS H 16 XL MILLER WELDER 2E
Country/Region of Manufacture: United States
